Smoked Pork

Yum

Smoked pork is a great BBQ item, not only because of the flavor but also the multitude of ways you can serve it. Sliced, pulled or shredded, on a bun or just by itself. There is also a multitude of ways to cook good smoked pork. Here is the way that I do it.

I like to marinade the pork shoulders or butts before I smoke them. The way to marinade I big cut like the shoulder is to inject it. The first step is to create the marinade. I use Butchers BBQ Pork Injection which I mix with some broth (beef or pork). I add some Worcestershire sauce, a little bit of garlic powder and some honey. I mix the ingredients together without heating up the marinade.

Before injecting the butt or shoulder, I like to trim some of the fat off the meat. You want to leave some on since it will add flavor but you can always trim off some of the fat cap. I also like to separate the Money Muscle. The Money muscle is perpendicular to the shoulder bone and it is the most succulent and tender part of the butt. You can either just remove some of the fat around the money muscle and cook it together with the butt or completely separate the muscle and cook it by itself. I prefer the latter.
​When the meat is trimmed, inject the butt with your marinade. Move throughout the butt and inject thoroughly.  Wrap tightly in plastic wrap  and refrigerate for at least 5 hours.

The next step is to give the outside of the pork its flavor, a great bark will make any pork stand out. Generously sprinkle your rub mix over each butt and let it sit for an hour - this will allow the rub to penetrate the meat and pull some of the water out. For this cook I used a mix of The Slabs and Swimmin in Smoke.

Light the smoker. I prefer to smoke pork at 235 degrees Fahrenheit. Make sure that you burn off the dirty smoke before you add the butts. The middle picture above has a thick gray smoke - this is dirty and could give the meat a bitter taste. You want a thin, blue smoke like the picture to the right. When it comes to pork I prefer apple, cherry or Maple.

Place the butts on the smoker with the fatter side up. Also place an aluminum pan underneath the butts to collect all the drippings - more about these later. 
Smoke for about 5 hours or until the internal temperature reaches about 165 degrees Fahrenheit. Turn the meat over and smoke for another hours so. The length depends on the size of the butts. You want the butts to start forming a nice red crust.

 When you have a nice bark - wrap the butts tightly in aluminum foil Keep smoking until the internal temperature reaches about 200 degrees Fahrenheit. While you wait for the butts to reach that temperature, collect all the drippings and pur into a tall container. Put the container in the fridge - the temperature will make the fat rise and get stiff. After an hour or so you can spoon out all the coagulated fat and you are left with liquid gold!! The juice from butts will be used later to add flavor to the sliced money muscle and the pulled and shredded pork.

If you have separated the money muscle, it needs much shorter cooking time. Normally I would put the money muscle in the smoker when I have about three hours left of the butts. I keep them unwrapped for about 2 hours or until they reach 165 degrees. I wrap them - just like you would do with the butts. And when they reach 200 degrees I pull them. One thing I like to do with the money muscle, is to give the outside a nice sweet glaze for a slightly different flavor profile than the rest of the pork. In this case I used some BBQ sauce, Agave honey, apple juice and marrionberry marmalade (seedless). I give the money muscle a finishing touch with the glaze and let it caramelize for about 30-45 minutes in the smoker.

The last step is to let the meat for a while. Then it is time to serve.
Use food handling gloves to pull the meat apart into nice chunks. Use a fork to shred some of the pork that is falling apart, and slice the money muscle into 3/4 inches thick slices.
​Dip the money muscle and pork chunks into the reserved drippings and pour back some of the dripping liquid into the shredded pork. Serve hot!!